李翠兵,李勇军,王爱民,黄勇,兰燕宇,何迅,王永林
LI Cuibing,LI Yongjun,WANG Aimin,HUANG Yong,LAN Yanyu,HE Xun,WANG Yonglin(School of pharmacology

• 1:贵阳医学院药学院

摘要(Abstract)：

目的:研究天泉通颗粒中挥发油的提取及β-环糊精包合的最佳工艺。方法:采用单因素分析考察最佳提取工艺,以收油率作为提取工艺的指标;采用正交试验考察最佳包合工艺,以包合物收得率和挥发油包合率作为评价包合工艺的指标。结果:挥发油提取的最佳工艺为加12倍量水,浸泡0.5 h,提取4 h;最佳包合工艺为:挥发油和β-环糊精包合比例为1 ml∶6 g,包合温度40℃,搅拌时间2 h。结论:所选提取工艺收油率高,包合工艺合理,节约成本。
Objective: To optimize the technology of volatile oil extraction and β-cyclodextrin compound inclusion of Tianquantong granules.Method: The extraction conditions were evaluated with single-factor analysis using oil-obtaining ratio as index;Orthogonal test was adopted to estimate the inclusion technology using oil-bearing ratio and inclusion ratio as indexes.Results: The optimal protocol for extraction was: soaking the granules in 12 folds of water in quantity for 30 minutes,extracted inoil for 3 hours.The best condition for inclusion was:the ratio of oil and β-cyclodextrin being 1mL: 6g,and stirring oil for 2 hours at 40℃.Conclusions: The extraction and inclusion conditions summarized in this study are suitable with high oil-extraction ratio,reasonable inclusion process,and minimum cost.

关键词(KeyWords)： 天泉通颗粒;挥发油;环糊精类;工艺学,制药
Tianquantong granules;oils,volatile;cyclodextrins;technology,pharmaceutical

Abstract:

Keywords:

基金项目(Foundation):

作者(Author): 李翠兵,李勇军,王爱民,黄勇,兰燕宇,何迅,王永林
LI Cuibing,LI Yongjun,WANG Aimin,HUANG Yong,LAN Yanyu,HE Xun,WANG Yonglin(School of pharmacology

DOI: 10.19367/j.cnki.1000-2707.2009.02.019

参考文献(References)：

• [1]靳怡然,杜英峰,袁志芳,等.戒毒胶囊制备工艺中挥发油提取及其β-环糊精包合工艺的研究[J].中成药,2008(11):1710-1712.
• [2]任文,叶强,茯徐齐.肠康宁片中挥发油的β-环糊精包合工艺研究[J].时珍国医国药,2007(2):448-449.
• [3]马雅斌,叶菊兰,瞿科峰.妇科调经胶囊中香附挥发油的提取及β-环糊精包合工艺的研究[J].新疆中医药,2008(5):36-38.
• [4]刘俊达,胡昌江,李兴华.理中汤配方颗粒挥发油包合工艺研究[J].中国药业,2007(16):29-30.
• [5]宋毅,潘晓鸥,唐尧,等.咽炎颗粒挥发油提取极其β-环糊精包合工艺的研究[J].中国中药杂志,2006(6):517-518.
• [6]郭晓雷,张箭.泡姜挥发油β-环糊精包合物的制备工艺研究[J].中国中药杂志,2003(1):87-88.

文章评论(Comment)：